Investigation on Effect of Flow Direction on Hydrodynamics for vertical Channel Bubbly Flow

M Pang, J Wei

Abstract


In order to fully understand hydrodynamics of the bubbly flow laden with microbubbles, the effect of flow direction on the phase distribution and the liquid–phase turbulence modulation in a vertical channel flow laden with microbubbles was detailedly investigated with a developed numerical method, where the liquid–phase velocity field was solved by direct numerical simulations and the microbubble trajectories were tracked by Newtonian equations of motion. The present investigations show the flow direction has the key influence on the phase distribution and the liquid–phase turbulence modulation; for the bubbly upflow, the overwhelming majority of microbubbles accumulate near the channel wall, the phase distribution display approximately the double–peaked distribution patter, and the liquid–phase turbulence was suppressed; for the bubby downflow, however, the microbubbles are far away from the channel wall to move towards the channel centre, the phase distribution shows roughly the off–center–peaked distribution pattern, and the liquid–phase turbulence was enhanced.


Full Text:

PDF

References


Giusti, A., Lucci, F., Soldati, A., 2005. Influence of the lift force in direct numerical simulation of upward/downward turbulent channel flow laden with surfactant contaminated microbubbles. Chem. Eng. Sci. 60(22), 6176–6187 CrossRef

Hibiki, T., Goda, H., Kim, S., Ishii, M., Uhle, J., 2004. Structure of vertical downward bubbly flow. Int. J. Heat Mass Transfer 47(8–9), 1847–1862 CrossRef

Kashinsky, O.N., Lobanov, P.D., Pakhomov, M.A., Randin, V.V., Terekhov, V.I., 2006. Experimental and numerical study of downward bubbly flow in a pipe. Int. J. Heat Mass Transfer 49, 3717–3727 CrossRef

Kashinsky, O.N., Randin, V.V., 1999. Downward bubbly gas–liquid flow in a vertical pipe. Int. J. Multiphase Flow 25(1), 109–138 CrossRef

Laín, S., Bröder, D., Sommerfeld, M., 2002. Modeling hydrodynamics and turbulence in a bubble column using the Euler–Lagrange procedure. Int. J. Multiphase Flow 28, 1381–1407. CrossRef

Legendre, D., Colin, C., Fabre, J., Magnaudet, J., 1999. Influence of gravity upon the bubble distribution in a turbulent pipe flow: Comparison between numerical simulations and experimental data. J. Chim. Phys. 96(6), 951–957 CrossRef

Legendre, D., Magnaudet, J., 1998. The lift force on a spherical bubble in a viscous linear shear flow. J. Fluid Mech. 369, 81–126. CrossRef

Lelouvetel, J., Nakagawa, M., Sato, Y., Hishida, K. 2011. Effect of bubbles on turbulent kinetic energy transport in downward flow measured by time–resolved PTV. Exp. Fluids 50, 813–823. CrossRef

Lelouvetel, J., Tanaka, T., Sato, Y., Hishida, K., 2014. Transport mechanisms of the turbulent energy cascade in upward/downward bubbly flows. J. Fluid Mech. 2014, 741, 514–542. CrossRef

Lu, J.C., Tryggvason, G., 2006. Numerical study of turbulent bubbly downflows in a vertical channel. Phys. Fluid. 18, 103302 CrossRef

Lu, J.C., Tryggvason, G., 2007. Effect of bubble size in turbulent bubbly downflow in a vertical channel. Chem. Eng. Sci. 62(11), 3008–3018 CrossRef

Ortiz–Villafuerte, J., Hassan, Y., 2006. Investigation of microbubble boundary layer using particle tracking velocimetry. J. Fluid Eng–T ASME 128(3), 507–519. CrossRef

Pang, M.J., Wei, J.J., Yu, B., 2010. Numerical study of bubbly upflows in a vertical channel using the Euler–Lagrange two–way model. Chem. Eng. Sci. 65, 6215–6228 CrossRef

Pang, M.J., Wei, J.J., Yu, B., 2011. Study on dependence of hydrodynamic characteristics on gravity in a vertical upward channel bubbly flow. Adv. Space Res. 48, 1392–1402 CrossRef

Sun, X., Paranjare, S., Ishii, M., Uhle, J.,2004. LDA measurement in air–water downward flow. Exp. Therm. Fluid Sci. 28, 317–328 CrossRef

Terekhov, V.I., Pakhomov, M.A., 2008. The Effect of bubbles on the structure of flow and the friction in downward turbulent gas–liquid flow. High Temperature, 46(6), 854–860. CrossRef




DOI: http://dx.doi.org/10.21152/1750-9548.10.4.379

Copyright (c) 2016 The International Journal of Multiphysics